Detroit Diesel
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (CPC) Coolant Temperature High
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If codes 110-3 or 110-4 also active, fix those first. NOTE: With a code engine, coolant inlet and coolant outlet temperature should be within 25 degree’s of each other. If not, replace both sensors. Otherwise, most PROBABLE CAUSES:1. Low coolant.2. Thermostat failure.3. Blockage in radiator and/or charge air cooler.4. Fan belt failure.5. Fan shroud failure or installed improperly.6. Radiator hose failure (collapsed hoses).7. Engine fan failure. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (MCM) Coolant Temperature High Alarm Detroit DD16 GHG14 (2014-16) Fault...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (MCM) Coolant Temperature High Alarm
Posted by PerDiezel Solutions on
DESCRIPTION:This code sets once the motor control module (MCM) detects that the outlet coolant temperature is above 112°C (234°F). MONITORED PARAMETER:Engine coolant outlet temperature sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL VERIFICATION:Engine idle: One minute. NOTE: If codes 110-3 or 110-4 also active, fix those first. NOTE: With a code engine, coolant inlet and coolant outlet temperature should be within 25 degree’s of each other. If not, replace both sensors. Otherwise, most PROBABLE CAUSES:1. Low coolant.2. Thermostat failure.3. Blockage in radiator and/or charge air cooler.4. Fan belt failure.5. Fan shroud...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 18 (MCM) Failed Coolant Thermostat (Coolant Heat Up Too Slow Compared to Modeled Coolant Temperature)
Posted by PerDiezel Solutions on
NOTE:No information available for this code. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (CPC) Coolant Temperature High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (MCM) Coolant Temperature High Alarm Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 15 (MCM) Coolant Temperature High Pre-Warning Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 14 (MCM) Coolant Temperature/Engine Oil Temperature Plausibility Fault Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 9 (ACM) Coolant Temperature Signal Not Available via Controller Area Network (CAN) Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 9 (MCM) Coolant...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 2 (MCM) Coolant Outlet Temperature Not Plausible
Posted by PerDiezel Solutions on
DESCRIPTION:Coolant outlet temperature not plausible. MONITORED PARAMETER:Coolant inlet and coolant outlet temperature sensors. TYPICAL ENABLING CONDITIONS:1. Engine speed 500-2500 rpm.2. Coolant temperature is greater than 65C.3. Battery voltage is 11 vDC.4. Run engine less than 60s. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:30 DASH LAMPS:MIL VERIFICATION:Start engine, warm it up so that the coolant temperature is greater than 65C. Insure battery voltage is 11 vDC and engine has been running for at least 1 minute then bring engine to idle speed, being certain that it is greater than 500 RPM. NOTE: If any other cooling system issues, repair those first....
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 3 (MCM) Engine Coolant Outlet Temperature Circuit Has Failed High
Posted by PerDiezel Solutions on
DESCRIPTION:Engine coolant outlet temperature circuit failed high. MONITORED PARAMETER:Engine coolant outlet temperature sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL VERIFICATION:Engine Idle: One minute. POSSIBLE CAUSES:1. Engine coolant outlet temperature sensor harness/connector.2. Engine coolant outlet temperature sensor. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 2 (MCM) Coolant Outlet Temperature Not Plausible Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 0 (MCM) Coolant Temperature High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 0 (MCM) Coolant Temperature High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 0...
