Detroit Diesel
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1077 FMI 7 (MCM) Rail Pressure Deviation is Greater the 200 Bar for Eight Seconds
Posted by PerDiezel Solutions on
NOTE: The motor control module (MCM) sets the code. POSSIBLE CAUSES:1. External fuel leakage between the high pressure pump and fuel injectors.2. Pressure limiting valve (PLV) leakage (Internal).3. Fuel filter integrity (Loose caps, plugged filters).4. Fuel supply issues (fuel level, fuel aeration, leaking fuel lines, fuel restrictions).5. Intermittent loss of engine speed signal.6. High pressure pump internal failure.7. Fuel injector (amplifier or needle) leakage.8. Fuel contamination.9. Rail pressure sensor.10. MCM. PROBABLE CAUSES:1. External fuel leakage betewen the high pressure pump and fuel injectors.2. Pressure limiting valve leakage (internal).3. Fuel filter integrity.4. Fuel suppply issue.5. Intermittent loss of engine speed signal.6....
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 13 (MCM, CPC, ACM) Ambient Air Pressure Signal Not Available via CAN
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If any engine computer modules have been programmed recently, clear the codes if they are not active. NOTE: Turn key off, disconnect batteries for 5 minutes. Reconnect. If codes still active, refer to code 625-9. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 4 (MCM) Barometric Pressure (BP) Sensor Circuit Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 4 (CPC) Air Filter Sensor Failed...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High
Posted by PerDiezel Solutions on
DESCRIPTION:Barometric pressure circuit failed high. MONITORED PARAMETER:Barometric pressure sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. NOTE: Replace the MCM (Engine ECM). Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 4 (CPC) Air Filter Sensor Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 3 (CPC) Air Filter Sensor Failed High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 2 (CPC) Air Filter Sensor Plausibility Error Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 0 (CPC) Air Filter Restriction...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 4 (MCM) Barometric Pressure (BP) Sensor Circuit Failed Low
Posted by PerDiezel Solutions on
DESCRIPTION:Barometric pressure circuit failed low. MONITORED PARAMETER:Barometric pressure sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. NOTE: The BP sensor is internal to the MCM. NOTE: Replace the MCM (Engine ECM). Detroit DD16 GHG14 (2014-16) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 4 (CPC) Air Filter Sensor Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 3 (CPC) Air Filter Sensor Failed High Detroit DD16 GHG14...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1089 FMI 9 (CPC) AIR 1 Message (Air Supply Pressure) Missing from First Source Address
Posted by PerDiezel Solutions on
NOTE:No information available for this code. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1077 FMI 31 (MCM) Fuel Rail Pressure Deviation is Greater than 200 Bar for Eight Seconds Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1077 FMI 15 (MCM) Internal or External Leakage of the High Pressure Fuel System Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1077 FMI 14 (MCM) Internal or External Leakage of the High Pressure Fuel System (Too High, Leak Down Test) Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1077 FMI 7 (MCM) Rail Pressure Deviation is Greater the 200 Bar for Eight Seconds Detroit DD16...
