Detroit Diesel
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 4 (MCM) Engine Coolant Outlet Temperature Circuit Failed Low
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the Motor Control Module (MCM) detects a short to ground on the engine coolant temperature sensor circuit. MONITORED PARAMETER:Engine coolant outlet temperature sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL VERIFICATION:Engine Idle: One minute. NOTE: Repair the short to ground between pin 2 of the engine coolant sensor harness connector and pin 110 of the MCM (Engine ECM) 120-pin connector. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 3 (MCM) Engine Coolant Outlet Temperature Circuit Has Failed High Detroit DD16 GHG14 (2014-16) Fault Code: SPN...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 9 (ACM) Coolant Temperature Signal Not Available via Controller Area Network (CAN)
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the coolant temperature signal is not received from the MCM. MONITORED PARAMETER:Outlet coolant temperature. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:10 Seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:None VERIFICATION:Ignition on NOTE: If any engine computer modules have been programmed recently, clear the codes if they are not active. NOTE: Turn key off, disconnect batteries for 5 minutes. Reconnect. If codes still active, refer to code 625-9. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 9 (MCM) Coolant Temperature Signal Not Available via Controller Area Network Detroit DD16 GHG14 (2014-16) Fault...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 9 (MCM) Coolant Temperature Signal Not Available via Controller Area Network
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If any engine computer modules have been programmed recently, clear the codes if they are not active. NOTE: Turn key off, disconnect batteries for 5 minutes. Reconnect. If codes still active, refer to code 625-9. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 4 (MCM) Engine Coolant Outlet Temperature Circuit Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 3 (MCM) Engine Coolant Outlet Temperature Circuit Has Failed High Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 2 (MCM) Coolant Outlet Temperature...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 1 (CPC) Coolant Level Very Low
Posted by PerDiezel Solutions on
DESCRIPTION:Coolant level below normal range. MONITORED PARAMETER:Coolant level TYPICAL ENABLING CONDITIONS:Always on MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:2 seconds DASH LAMPS:CEL ENGINE REACTION:1. No reaction.2. Shutdown depending on parameter settings. VERIFICATION:Cycle key NOTE: If any other active fault codes, fix those first. PROBABLE CAUSES:1. Low coolant.2. Coolant level sensor connector/harness.3. Coolant level sensor.4. Cooling system leaks.5. Radiator cap failure. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 18 (MCM) Failed Coolant Thermostat (Coolant Heat Up Too Slow Compared to Modeled Coolant Temperature) Detroit DD16 GHG14 (2014-16) Fault Code: SPN 110 FMI 16 (CPC) Coolant Temperature...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 18 (CPC) Coolant Level Low
Posted by PerDiezel Solutions on
DESCRIPTION:Coolant level below normal range. MONITORED PARAMETER:Coolant level TYPICAL ENABLING CONDITIONS:Always on MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:Two seconds DASH LAMPS:CEL ENGINE REACTION:None VERIFICATION:Cycle key NOTE: If any other active fault codes, fix those first. PROBABLE CAUSES:1. Low coolant.2. Coolant level sensor connector/harness.3. Coolant level sensor.4. Cooling system leaks.5. Radiator cap failure. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 6 (CPC) Coolant Level Sensor Circuit Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 4 (CPC) Coolant Level Circuit Failed Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 3 (CPC)...
