Detroit Diesel
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 524 FMI 9 (CPC) J1939 ETC2 Message Missing
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the motor control module (MCM) detects that there is EGR pressure when the engine is not running. MONITORED PARAMETER:EGR delta pressure. TYPICAL ENABLING CONDITIONS:Coolant temperature greater than 80°C (176°F) and ignition is cycled off for 10 seconds. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:15 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:1. Run the engine until the coolant temperature is greater than 80°C (176°F).2. Turn the ignition off for 15 seconds.3. Turn the ignition on as a recheck for the fault code. PROBABLE CAUSES:1. EGR delta p sensor failure.2. EGR delta...
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 527 FMI 9 (CPC) J1939 Cruise Control Vehicle Speed (CCVS) Message from Source #1, #2, #3 Missing
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the motor control module (MCM) detects that there is EGR pressure when the engine is not running. MONITORED PARAMETER:EGR delta pressure. TYPICAL ENABLING CONDITIONS:Coolant temperature greater than 80°C (176°F) and ignition is cycled off for 10 seconds. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:15 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:1. Run the engine until the coolant temperature is greater than 80°C (176°F).2. Turn the ignition off for 15 seconds.3. Turn the ignition on as a recheck for the fault code. PROBABLE CAUSES:1. EGR delta p sensor failure.2. EGR delta...
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 5444 FMI 1 (MCM) Engine Crankcase Breather Oil Separator Speed Too Low
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. PROBABLE CAUSES:1. Oil leak at the crankcase oil separator vent.2. Crankcase breather speed sensor connector/harness.3. Crankcase breather speed sensor.
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 558 FMI 1 (CPC) Incorrect Wiring of the Idle Validation Switch
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the motor control module (MCM) detects that there is EGR pressure when the engine is not running. MONITORED PARAMETER:EGR delta pressure. TYPICAL ENABLING CONDITIONS:Coolant temperature greater than 80°C (176°F) and ignition is cycled off for 10 seconds. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:15 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:1. Run the engine until the coolant temperature is greater than 80°C (176°F).2. Turn the ignition off for 15 seconds.3. Turn the ignition on as a recheck for the fault code. PROBABLE CAUSES:1. EGR delta p sensor failure.2. EGR delta...
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 558 FMI 2 (CPC) Idle Validation Switch Inputs Reversed
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the motor control module (MCM) detects that there is EGR pressure when the engine is not running. MONITORED PARAMETER:EGR delta pressure. TYPICAL ENABLING CONDITIONS:Coolant temperature greater than 80°C (176°F) and ignition is cycled off for 10 seconds. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:15 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:1. Run the engine until the coolant temperature is greater than 80°C (176°F).2. Turn the ignition off for 15 seconds.3. Turn the ignition on as a recheck for the fault code. PROBABLE CAUSES:1. EGR delta p sensor failure.2. EGR delta...
