Detroit Diesel
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 120 FMI 13 (CPC) Retarder Fluid Message is Missing or Not Available
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If code 164-0, 168-14, or 168-18 are present, fix those first. NOTE: If code 625-9 present, fix that first. NOTE: If any engine module has been programmed recently, check to make sure it was programmed properly. NOTE: Otherwise, the problem is another computer on the vehicle causing the problem (Transmission, cab, ABS, etc…) Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 19 (MCM) Coolant Level Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 18 (CPC) Coolant Level Low Detroit DD16 GHG14 (2014-16) Fault...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1231 FMI 9 (MCM) Aftertreatment Control Module Message Not Received or Has Stopped Arriving
Posted by PerDiezel Solutions on
DESCRIPTION:This fault code sets when the motor control module (MCM) stops receiving messages from the aftertreatment control module (ACM). MONITORED PARAMETER:ACM controller area network (CAN) communication. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL is solid2. CEL and AWL Flash ENGINE REACTION:30 seconds shutdown. VERIFICATION:1. Turn the ignition off.2. Disconnector the USB link from the 9 – pin connector.3. Wait five minutes.4. Reconnect the USB link and diagnostic service tool.5. Turn the ignition on and recheck for the fault code. NOTE: If there are any battery voltacodes, fix those first. If the ECM...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1243 FMI 14 (CPC) Antilock Brake System Fault Restricts Automatic Gear Selection Functionality
Posted by PerDiezel Solutions on
NOTE: This fault code indicates a missing message from the antilock brake system (ABS) module. PROBABLE CAUSES:1. If any battery voltage codes present, fix those first.2. If any 625-xx codes, fix those first.3. If the CPC4 has been recently programmed, ensure the parameters are correct.4. Turn key off for 5 minutes, then turn back on. Check codes. If not active, clear codes and release. if active, refer to code 625-9. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1327 FMI 4 (CPC) Stop Engine Override Switch Short Circuit to Ground Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1231 FMI 9 (MCM)...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 132 FMI 1 (MCM) Air Mass Flow Too Low
Posted by PerDiezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If any other codes are present, repair them first Otherwise, check the following for restrictions/failures:1. Plugged inlet air filters.2. Charge air cooler leaks.3. Intake manifold leaks.4. Exhaust system leaks. Detroit DD16 GHG14 (2014-16) Fault Code: SPN 120 FMI 13 (CPC) Retarder Fluid Message is Missing or Not Available Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 19 (MCM) Coolant Level Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 18 (CPC) Coolant Level Low Detroit DD16 GHG14 (2014-16) Fault Code: SPN 111 FMI 6...
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1322 FMI 31 (MCM) Multiple Cylinder Misfire Detected at Idle
Posted by PerDiezel Solutions on
The Entry Conditions For This Code Are:1. Engine speed is above low idle.2. All cylinders are active, no fault reactions.3. Engine speed/torque is steady. This Fault Can Occur Due To The Conditions Listed Below:1. Cylinder kit failure.2. Valve train failure.3. Lash adjustments.4. Fuel injector.5. High pressure fuel line (Rail to fuel injector).6. Debris entering fuel injector (intermittent faults).7. Fuel quality. PROBABLE CAUSES:1. Cylinder kit failure.2. Valve train failure.3. Lash adjustments.4. Fuel injector.5. High pressure fuel line (rail to fuel injector).6. Debris entering fuel injector.7. Fuel quality. Note: If 1322-31 active, fix that first. Detroit DD16 GHG14 (2014-16) Fault Code: SPN...
