Volvo
Volvo All Engines (2010 Emissions) Fault Code: SPN 1761 FMI 4 PID: PPID 278 Aftertreatment Diesel Exhaust Fluid (DEF)
Posted by PerDiezel Solutions on
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor has an indicator lamp and gauge in the instrument cluster. A solid lamp comes on when there is approximately 16% DEF remaining in the tank. A flashing lamp indicates when there is approximately 4% DEF remaining in the tank. A 25% engine derate is possible if the DEF is not refilled above the red line on the gauge at the next engine start up. Conditions for diagnostic trouble code (DTC):1) Short circuit to ground in the component or wiring2) Short circuit to lower voltage Observable symptoms1) The Aftertreatment diesel exhaust fluid (DEF)...
Volvo All Engines (2010 Emissions) Fault Code: SPN 1761 FMI 5 PID: PPID 278 Aftertreatment Diesel Exhaust Fluid (DEF)
Posted by PerDiezel Solutions on
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor has an indicator lamp and gauge in the instrument cluster. A solid lamp comes on when there is approximately 16% DEF remaining in the tank. A flashing lamp indicates when there is approximately 4% DEF remaining in the tank. A 25% engine derate is possible if the DEF is not refilled above the red line on the gauge at the next engine start up. Conditions for diagnostic trouble code (DTC):1) The voltage at pin A137:46 is below normal value Observable symptoms1) The Aftertreatment diesel exhaust fluid (DEF) tank level gauge remains permanently...
Volvo All Engines (2010 Emissions) Fault Code: SPN 177 FMI 0 PID: Transmission Oil Temperature
Posted by PerDiezel Solutions on
The J1587 and J1939 serial data lines are used as the standard communication link for on-board vehicle instrumentation, off-board service diagnostics and fleet management.The transmission oil temperature sensor sends a signal to the instrument cluster module which relays a signal to the engine control module (ECM) via the data link. The signal is used to demand fan activation. If the transmission oil temperature gets too high, a yellow check lamp or red stop lamp will illuminate. The engine will also derate. Observable symptoms1) Engine de-rated Probable cause1) Low oil level, Transmission2) Oil temperature sensor3) Oil cooler4) Transmission overloaded Volvo All...
Volvo All Engines (2010 Emissions) Fault Code: SPN 177 FMI 16 PID: Transmission Oil Temperature – Moderately Severe Level
Posted by PerDiezel Solutions on
The J1587 and J1939 serial data lines are used as the standard communication link for on-board vehicle instrumentation, off-board service diagnostics and fleet management.The transmission oil temperature sensor sends a signal to the instrument cluster module which relays a signal to the engine control module (ECM) via the data link. The signal is used to demand fan activation. If the transmission oil temperature gets too high, a yellow check lamp or red stop lamp will illuminate. The engine will also derate. Probable cause1) Low oil level, Transmission2) Oil temperature sensor3) Oil cooler4) Transmission overloaded Volvo All Engines (2010 Emissions) Fault...
Volvo All Engines (2010 Emissions) Fault Code: SPN 188 FMI 0 PID: Engine Speed at Idle, Point 1
Posted by PerDiezel Solutions on
Conditions for diagnostic trouble code (DTC):1) Engine Speed at idle, Above normal Observable symptoms1) Idle Above normal2) High oil consumption Probable cause1) Parameter code, unit injector2) Injector3) Fuel4) Internal Oil leakage5) Low compression Volvo All Engines (2010 Emissions) Fault Code: SPN 177 FMI 16 PID: Transmission Oil Temperature – Moderately Severe Level Volvo All Engines (2010 Emissions) Fault Code: SPN 177 FMI 0 PID: Transmission Oil Temperature Volvo All Engines (2010 Emissions) Fault Code: SPN 1761 FMI 5 PID: PPID 278 Aftertreatment Diesel Exhaust Fluid (DEF) Volvo All Engines (2010 Emissions) Fault Code: SPN 1761 FMI 4 PID: PPID 278...
